Our Liberty Fat-Quarter bundles are the perfect starting place for a set of beautiful picnic ready napkins. All ten napkins have a different print and a sweet, retro, embroidered edge.  A soft white picnic cloth rounds out the set, perfect for a Memorial Day picnic!  Enjoy! --Molly

• One Liberty Fat Quarter Pack in blues
• 1 ball of Valdani embroidery thread in Light Blue
• 1 ball of Valdani embroidery thread in Pink
• 3 yards of Kona Cotton in White
  

• 1-1/2 yards Moda Wide Muslin in White (The wide muslin is 108-inches wide and its width is specific to this pattern).
  
• 1 ball of Valdani embroidery thread in Light Blue
• 1 ball of Valdani embroidery thread in Pink

Cut Fabric

• Cut each of the Liberty Fat-Quarters into 17-inch x 17-inch squares
• Cut ten 17-inch x 17-inch squares from the white Kona Cotton

(For help cutting check out my Rotary Cutting Tutorial.)

Pin + Sew Fabrics

• Pin each Liberty piece to a Kona Cotton piece with the right sides facing, leave a spot for a 3-inch opening along one side for turning the napkin right-side out when you're done sewing.
• Sew a 1/2-inch seam all the way around, remember to leave a 3-inch opening along one side. Back stitch at the beginning and end of each seam.
  

Finish Napkin

• Snip off the corners approximately 1/8-inch from the seam.
• Turn the napkin right-side out through the 3-inch opening. Make sure the corners are nice and pointy (a knitting needle works well for this, just be careful not to poke it through the fabric!).
• Tuck the seams of the 3-inch opening neatly inside the napkin and press carefully. This will make closing it in the next step a breeze.
  

Running Stitch

• Thread a 24-inch length of blue embroidery thread and tie a small knot at the end, leaving a 3-inch tail. (You'll need 3 lengths of thread to go around the entire napkin.)
• Sew a simple running stitch 1/4-inch from the edge of the napkin. (A running stitch simply goes in and out of the fabric as shown in the photo above).
• As you stitch around the napkin you will be catching the inside of the seam allowance, which will close the 3-inch opening you left for turning the napkin right-side out.
• Leave a 3-inch tail at the end of the thread and tie a simple knot.
  

Hiding the Ends 

• Thread your needle with one of your tails.
• Place your needle back into the spot where the thread came out. Slip your needle between the two fabric layers for one inch and then poke the needle back out through the same side of the fabric.
• Give the thread a little tug and clip it close to the fabric, pull the fabric flat and the thread end will disappear between the layers. Repeat for all of the thread ends.

You can stop here and have a very pretty, simple napkin or follow the next step directions for a fancier version.

Triangle Stitch 

I don't know what to call this little pink edge stitch. If anyone knows it's proper name please let us know. For now I'll call it the "triangle stitch." 

• Thread a 24" length of pink embroidery thread and tie a small knot 3-inches from the end.
• Pull the needle through a few threads of the very edge of the Kona Cotton side of the napkin, in between two of the blue stitches as shown above.
  

• Pull the pink thread down through the left side of the right hand running stitch and back up through the right side of the left hand running stitch as pictured above.

• Place your needle into the top fold of the Kona Cotton, a few threads to the right of the knot, so the thread over laps itself a little. 
• Slip the needle through this fold (do not poke through to the Liberty side of the napkin) and pull your needle out along the top fold, in between the two next running stitches as pictured above.

• When you pull the pink thread the "triangle" will appear.
• Repeat all the way around the napkins edge and hide the ends in the same way as in Step One, above.

Rip + Pin Fabric

After you've washed and pressed the fabric you'll need to get the large piece straight. Since the Moda Wide Muslin is so wide the easiest way to get a straight line along one edge is to rip it.

• Begin with a 1-1/2 yard length of fabric (108-inches wide x 54-inches long).
  
• Make two little snips about 1 inch from both of the raw edges and rip along the whole width (selvage to selvage) of the fabric along each side.  The ripped piece should measure approximately 108-inches wide x 52-inches long.
  
• Press ripped edges to get them flat again.
  
• I know it's a bit of a cheat, but we will not be cutting off the selvages of the fabric. Instead, fold the fabric in half so that the selvages meet. Make sure everything is laying as flat as possible and pin around all three open edges (the fourth edge is closed because it's a fold).
• Leave a 5-inch opening along one side for turning the cloth right-side out when you're done sewing.
  

Sew Cloth 

• With a 5/8-inch seam allowance sew the 3 pinned sides together, remember to leave a 5-inch opening in the middle of one side for turning the cloth right-side out.
• Back stitch at the beginning and end of your seam. 
• Snip the corners approximately 1/8-inch from the corner seams.
• Turn the piece right-side out through the 5-inch opening, poke the corners out for a sharp point, just like you did for the napkins.
• Press the cloth being sure to iron the gap so that the seam allowances are neatly tucked inside.
  
• Pin around all four sides of the cloth.

• Top stitch with a 1/2-inch seam along all sides of the blanket, crossing each corner as shown above. Back stitch at the beginning and end of each side. The top stitching will close the gap! 

embroider edges, step one

• Using the blue embroidery thread, follow the steps for embroidering the edges of the napkins (part one) with a running stitch from above.
  

embroidering the edge, step two

• Using the pink embroidery thread, follow the steps for embroidering the edges of the napkins (part two) with the triangle stitch from above, completing 10 triangle stitches on either side of every corner.  (This way the pretty triangle stitch is still represented but you don't have to drive yourself crazy doing it all the way around the cloth!)

Iron the cloth one last time, pack up some sandwiches, and have a great Memorial Day!